DESMI Ocean Guard
DESMI Ocean Guard RayClean Receives Type Approval
- Company Details
- Products & Services
- White Papers
- Press Releases
- Regional Offices
- Contact Company
DESMI Ocean Guard RayClean Receives Type ApprovalDESMI Ocean Guard
The ground-breaking new ballast water treatment system RayClean, developed by DESMI Ocean Guard, has received IMO and DNV type approval.
On 5 September DNV GL issued type approval certificate for the RayClean system. The type approval certificate includes approval according to both the IMO Ballast Water Management Convention and the DNV type approval programme.
The type approval is unique because this is the first time a ballast water treatment system has been tested fully according to both IMO and US Coast Guard requirements. This is also revealed on the certificate, where it is stated that the RayClean system has undergone 15 land-based tests, five in each salinity, and five ship-board tests as per US Coast Guard test requirements. IMO requires ten land-based tests in two salinities, and three ship-board tests.
But the RayClean system has undergone much more additional testing than this in order to comply with the US Coast Guard test requirements. During land-based testing a so-called "operation & maintenance" test with treatment of 10,000t of ballast water has been performed and the electrical equipment in the system has been through significantly more demanding vibration tests than required by IMO, just to mention a few. This, combined with the fact that only the US Coast Guard approved Independent Lab and test facilities were used throughout the entire testing programme, puts the RayClean system in pole position for the US Coast Guard type approval, which no system has been awarded yet.
The RayClean system is based on filtration and highly efficient UV treatment with low pressure UV lamps. The performance demonstrated by the RayClean system during the extensive approval testing is second to none, and this is documented on the certificate where the following is stated:
- Approved for operation in all salinities
- Approved for operation in all sea temperatures
- Approved for treatment of water with UV-transmission anywhere from 33% to 100%
In particular, the industry leading performance in water with low UV-transmission makes RayClean the new benchmark for the industry.
DESMI Ocean Guard CEO Rasmus Folsø said: "When we started the development and approval of the RayClean system three years ago, it was clear to us that not only should the system be approved to work in all salinity regimes, we also wanted a system that would be able to treat water in compliance with the IMO and USCG discharge requirements everywhere in the world. And this is where the UV-transmission limitation comes into the picture.
"Several of the world's most busy ports are located at river estuaries, where fresh water with very low UV-transmission constantly fills the port basin. Shanghai is an example of this, and here we have measured UV-transmission values significantly below 50%. However, there are only two UV-based ballast water treatment systems in the world, to date, which are certified for treatment of water with UV-transmission of for example 40%; the two DESMI Ocean Guard systems, OxyClean and RayClean.
"We experience that this issue receives more and more attention from shipowners, because it could potentially cause big problems during operation of the vessel. If you operate a ballast water treatment system in water with a lower UV-transmission than what the system is approved for, the system will generate an alarm, which will be stored in the log of the system. When arriving at for example a US port the authorities will require documentation regarding the ballast water you wish to discharge, and part of this documentation is the ballast water treatment system log. If this shows an alarm for too low UV-transmission, the ballast water has not been treated according to requirements and the shipowner may not be allowed to discharge the ballast water."
The RayClean system will be displayed during the SMM exhibition in Hamburg from 9-12 September. Please visit us at the DESMI stand in the Danish Pavilion, stand no B1.EG.310, for a talk about the RayClean system, its superior UV-transmission performance, our road to US Coast Guard type approval, and why the system is a perfect match for DESMI's already existing product portfolio and worldwide sales and service networks for the maritime industry.